Model year 2019 · Compact Cars, Large Cars, Small Station Wagons
2019 BMW 3 Series: recalls, fuel economy and safety ratings
EPA rates the 2019 BMW 3 Series at 23–30 mpg combined across 5 versions. NHTSA lists 9 safety recalls and 41 owner complaints for this model year. Its best NHTSA overall crash-test rating is 5 out of 5 stars.
Safety recalls
9
EPA combined mpg
23–30
NHTSA overall rating
5/5
Recall file dated Oct 27, 2026 · EPA file dated Sep 29, 2026 · updated Oct 27, 2026, 7:34 AM EDT
NHTSA lists this vehicle as 330I, M340I.
Check your own car: enter your 17-character VIN at nhtsa.gov/recalls to see open recalls for that exact vehicle, and contact a BMW dealer to schedule the repair — safety recall repairs are free. The list below covers the whole model year, so not every recall applies to every car.
2019 BMW 3 Series recalls
NHTSA's recall file lists 9 safety recalls for the 2019 BMW 3 Series, newest first.
Electrical system: Starter assembly: Relay
NHTSA 25V636000Reported Sep 23, 2025Park outside
Filed by
BMW of North America, LLC
Units affected
199,674 (estimate)
Problem
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Risk
A short circuit in the starter relay may increase the risk of a fire.
Remedy
Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
BMW of North America, LLC (BMW) is recalling certain 2019-2022 330i, 330i xDrive, M340i, 2022 430i Coupe, 2021-2022 430i, M440i Convertible, and 2020-2022 228i xDrive Gran Coupe vehicles. The receiver audio module control unit software may fail to properly generate audible seat belt warnings to the driver to fasten their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk
An audible chime that does not properly alert the driver to fasten their seat belt increases the risk of injury in a crash.
Remedy
Dealers will update the receiver audio module software, free of charge. Owner notification letters were mailed October 12, 2023. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2019-2021 330i, 330i xDrive, M340i xDrive, 2020-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, 2021 X3 xDrive30e, X4 xDrive30i, and X4M vehicles. The seat frame may not have been welded properly to the seat rails.
Risk
An improperly welded seat frame may not properly restrain the occupant during a crash, increasing the risk of injury.
Remedy
Dealers will replace the seat frame and back rest, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact BMW customer service at 1-800-525-7417.
Back over prevention: Software and 1 more component
NHTSA 21V096000Reported Feb 19, 2021
Filed by
BMW of North America, LLC
Components
Back over prevention: Software; Back over prevention: Sensing system: Camera
Units affected
13,858 (estimate)
Problem
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply…
Risk
If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy
BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (manufacturer recall no. Toyota: 20TA09)
Units affected
2,779 (estimate)
Problem
BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.
Risk
A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
Remedy
BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
BMW of North America, LLC (BMW) is recalling certain 2019-2020 330i and 330i xDrive vehicles. The outboard rear seat belt pretensioners may not lock as intended during a crash.
Risk
In the event of a crash, if the seat belt pretensioners fail to lock, there is an increased risk of injury.
Remedy
BMW will notify owners, and dealers will replace the rear seat belts, free of charge. The recall is expected to begin February 10, 2020. Owners may contact BMW customer at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2019-2020 330i, 330i xDrive, and 2019 Z4 vehicles. The needle roller bearings of the counterbalance shafts may have been improperly installed, potentially causing the counterbalance shaft to loosen.
Risk
If the counterbalance shaft loosens, severe engine damage could occur, increasing the risk of a crash.
Remedy
BMW will notify owners, and dealers will replace the engine, free of charge. The recall began December 13, 2019. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of…
Risk
The lack of an image in the back-up camera display increases the risk of a crash.
Remedy
BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
BMW of North America, LLC (BMW) is recalling certain 2019-2020 230i, 230i xDrive, M240i, M240i xDrive, M2 Competition Coupe, 430i, 430i xDrive, 440i, 440i xDrive, M4, and 2019 330i xDrive Sportswagon vehicles. The driver and passenger knee air bag assemblies may have been improperly folded and assembled.
Risk
An improperly folded and assembled air bag may not deploy as intended, increasing risk of injury.
Remedy
BMW will notify owners, and dealers will replace the knee air bag modules, free of charge. The recall began July 8, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Recall summaries are written by NHTSA from manufacturers' defect reports. Dates are when NHTSA received the report.
Advertisement
2019 BMW 3 Series fuel economy by version
EPA city/highway/combined estimates for each engine, transmission and drive combination. Annual fuel cost is EPA's estimate for 15,000 miles a year (55% city, 45% highway) at EPA's current fuel-price assumptions; your cost will vary.
Source: FuelEconomy.gov (U.S. DOE and EPA), file dated Sep 29, 2026. Each version links to its FuelEconomy.gov record.
EPA estimates come from standardized lab tests so cars can be compared fairly; real-world mileage depends on speed, weather, load, tires and driving style.
2019 BMW 3 Series crash-test ratings
NHTSA 5-Star Safety Ratings for the tested versions. More stars mean a lower chance of serious injury in that type of crash. Rollover risk is NHTSA's estimated chance of rolling over in a single-vehicle crash.
2019 BMW 3 Series NHTSA 5-Star Safety Ratings
Tested vehicle
Overall
Frontal
Side
Rollover
Rollover risk
Forward collision warning
2019 BMW 3 Series 4 DR AWD
Not rated
Not rated
Not rated
Not rated
—
Standard
2019 BMW 3 Series 4 DR RWD
Not rated
Not rated
Not rated
Not rated
—
Standard
2019 BMW 3 Series GT 5 HB AWD
5 stars
4 stars
5 stars
5 stars
9.5%
Standard
2019 BMW 3 Series SW AWD
5 stars
4 stars
5 stars
5 stars
9.5%
Standard
Source: NHTSA 5-Star Safety Ratings (New Car Assessment Program), checked Oct 26, 2026.
Star ratings compare vehicles of similar size and weight; a frontal rating for a large pickup is not directly comparable with one for a small car.
Advertisement
2019 BMW 3 Series owner complaints
Owners have filed 41 complaints with NHTSA about the 2019 BMW 3 Series, most recently on Aug 26, 2026. 2 mention a crash, 5 a fire, 2 injured people and 0 deaths. These are unverified reports; a complaint is not proof of a defect.
Most-cited components in 2019 BMW 3 Series complaints
Component named in complaints
Mentions
Engine
9
Unknown or other
9
Electrical system
7
Air bags
4
Power train
4
Exterior lighting
3
Electronic stability control (ESC)
2
Lane departure: Assist
2
Lane departure: Warning
2
Vehicle speed control
2
Source: NHTSA consumer complaint files (complaints received since January 1, 2015). One complaint can name several components.
